1、T35-11軸流風機一、風機的用途T35-11軸流通風機為節能新產品，具有結構簡單，效率高，振動小，噪聲較低的特 點。適用于一般工作場所、倉庫、住宅、建筑物的通風換氣；或加強暖氣散熱之用，假 設將機殼去掉亦可作自由風扇；也可在較長的排氣管道間隔串聯安裝，以提高管道中的 全壓。輸送介質為枯燥的空氣與無腐蝕性、 不自然、不含有粘性物質，輸送介質的溫度, 不得超過60C，介質中所含的塵土與硬質顆粒不得大于 150毫克/立方米。二、風機的型式1、該風機共有十三種規格可供選擇。機號為 NO2.8; 3.15 ; 3.55 ; 4; 4.5 ; 5; 5.6 ; 6.3 ; 7.1 ; 8; 9; 10;

2、 12;2、風機選用不同極數的電機與葉輪直接聯接。風機外殼為直筒形，面對進風器端 看葉輪旋轉方向為逆時針方向。三、使用、安裝與維修1、本系列通風機假設在較長的管道，同機號的通風機可串聯，以增高風壓。2、通風機不得倒吊使用。3、安裝前詳細檢查是否因包裝、運輸而損壞、變形，假設有待修理妥善后，才能 進展安裝。4、安裝時要注意檢查各聯接局部有無松動，葉輪葉片與風筒間隙應均勻，不得相 碰。5、連接出風口之管道重量不應由風筒承受，安裝時應加支撐，在通風機進風口處 應安裝進風口，并裝好防護鐵絲網。&風機底座必須與地基平面自然接合，不得敲打底座強制聯接，以防底盤變形。 安裝時應校正底座，加墊鐵片，根

3、本保持水平位置然后再將地腳螺母旋緊。7、風機長期未使用，必須先進展檢查各聯接局部是否結實可靠，葉輪與風筒間隙 是否適宜，并經試運轉后，方可正式使用。8、經常注意風機在運轉中有無異常聲響，振動是否加大，并應與時檢查修理。9、風機正式運轉后每半年檢查一次。本說明書僅供參考，具體數據容有變動。T35、BFT35型軸流通風機性能表機號No.葉 輪 直 徑mm葉輪 周速m/s主軸 轉速 r/min葉片 角度O風量m3/h全壓Pa全壓 效率 %需用 軸功 率kw采用 軸功率kw配用電動機型號功率kw2.828042.529001512241280.640.0680.078YSF-56220.1220174

4、21410.680.1000.115YSF-56320.1802525601430.690.1470.169YSF-56320.1803024951650.680.1680.193YSF-63220.3503527781860.640.2240.258YSF-63320.37021.5145015613320.640.00850.0097YSF-50140.0252087335.20.680.01260.015YSF-50140.02525113335.70.690.01630.016YSF-50140.02530125141.20.680.0210.024YSF-50240.04035139

5、246.60.640.02820.032YSF-50240.0403.1531547.82900151944170.10.670.1370.158YSF-63120.180202681186.60.710.1960.225YSF-63220.250253418189.20.720.2500.288YSF-63320.370303753217.70.710.3200.368YSF-71220.5503541552470.670.4250.489YSF-71220.55023.914501597242.50.670.0170.020YSF-50140.02520134046.60.710.0240

6、.028YSF-50240.04025170947.20.720.0310.036YSF-50240.04030187754.90.710.0400.046YSF-56140.06035207861.70.670.0530.061YSF-56240.0903.5535553.92900152783216.10.670.2490.286YSF-71120.3702038392370.710.3560.409YSF-71220.550254895240.30.720.4540.523YSF-71320.7503053752790.710.5870.673YSF-71320.750355951313

7、.60.670.770.886YSF-80221.127.01450151394540.670.0310.036YSF-50240.04020192359.20.710.0450.052YSF-56140.06025245260.20.720.0570.066YSF-56240.09030269269.70.710.0740.085YSF-56240.09035298178.40.670.0950.109YSF-63140.120機號No.葉 輪 直 徑mm葉輪 周速m/s主軸 轉速 r/min葉片 角度O風量m3/h全壓Pa全壓 效率 需用 軸功 率 kw采用 軸功率kw配用電動機型號功率k

8、w440060.72900153980274.30.670.4530.521YSF-7132.75205489300.90.710.6460.743YSF-80221.1256999305.10.720.8240.948YSF-80221711.0641.224YT90S-21.5358500398.20.671.3841.592YT90S-22.230.4145015199368.60.670.0570.066YSF-56240.09020274975.20.710.0810.093YSF-63140.1225350576.20.720.1030.118YSF-63

9、240.1830384988.50.710.1410.162YSF-63240.1835426199.50.670.1730.169YSF-71140.254.545034.2145015283886.80.670.1020.117YSF-63140.12020391495.20.710.1460.168YSF-6324050.720.1860.214YSF-71140.2503054801120.710.2400.276YSF-71240.3703560671260.670.3170.364YSF-71240.370550038.01450154289112.60.

10、670.1890.217YSF-71140.250205763124.80.710.2660.306YSF-71240.370257273129.60.720.3380.389YSF-80140.550307907145.60.710.4260.490YSF-80140.550358712164.60.670.5610.645YSF-80240.75025.196015283949.10.710.0550.035YSF-80260.37020381554.40.750.0770.089YSF-80260.37025479256.80.770.0980.112YSF-80260.37030523

11、563.50.750.1230.141YSF-80260.37035576871.80.710.1620.186YSF-80260.3705.656042.51450156025140.90.710.3320.382YSF-71240.370208097156.10.750.4680.538YSF-80140.5502510168162.60.770.5900.686YSF-80240.7503011110182.10.750.7490.861YT90S-41.135122392060.710.9861.137YT90S-41.128.196015398961.80.710.0960.110Y

12、SF-80260.37020536168.40.750.1360.156YSF-80260.37025673271.30.770.1730.199YSF-80260.37030735579.80.750.2100.241YSF-80260.37035810390.30.710.2860.329YSF-80260.370機號No葉輪 直徑mm葉輪 周速m/s主軸 轉速 r/min葉 片 角 度O風量m3/h全壓Pa全壓 效率%需用 軸功 率 kw采用 軸功率kw配用電動機型號功率kw6.363047.81450158579178.30.710.5980.688YSF-80240.75020115

13、28197.60.750.8440.971YT90S-41.12514477205.80.771.0751.236YT90S-41.53015817230.50.751.3501.553YT90L-41.53517426260.70.711.7772.044YT100L-42.231.796015568078.20.710.1742.00YSF-80260.37020763286.60.750.2450.282YSF-80260.37025958590.20.770.3120.359YSF-80260.3703010472101.00.750.3920.451YT90S-60.75035115

14、32114.30.710.5160.680YT90S-60.7507.171053.914501512280226.50.711.0881.251YT90L-41.52016501250.90.751.5331.763YT100L1-42.22520722261.40.771.9542.247YT100L2-433022641292.70.752.4542.822YT100L2-433524944331.10.713.233.715YT112M-4436.796015813099.30.710.3160.363YT90S-60.7520109251100.750.4450.512YT90S-6

15、0.752517320114.60.770.5670.652YT90S-60.753014990128.40.750.7130.820YT90L-61.753516514145.20.710.9381.079YT90L-61.1880060.714501517567287.60.711.9762.272YT100L2-432023605318.60.752.7853.203YT112M-442529644331.80.773.5484.081YT132S-45.53032389371.60.754.4585.127YT132S-45.53535682420.30.715.8676.747YT1

16、32M-47.540.26601511630126.10.710.5740.660YT90S-60.752015628139.60.750.8080.929YT90L-61.12519626131.10.770.9281.067YT90L-6190.751.2941.488YT100L-61.53523624184.20.711.7031.958YT112M-62.2990045.29601516560159.50.711.0341.809YT100L-61.82022252176.70.751.4561.674YT112M-62.22527944184.10.771

17、.8562.134YT112M-62.23030532206.20.755.3312.680YT132S-633533937233.20.713.0693.529YT132M1-64機號No葉輪直徑mm葉 輪 周 速 m/s主軸 轉速 r/min葉 片 角 度O風量m3/h全壓Pa全壓 效率 %需用軸 功率kw采用 軸功 率kw配用電動機型號功率kw10100050.396015227161970.711.752.013YT112M1-62.22030524218.20.752.4672.837YT132S-632538333227.30.773.1433.615YT132M1-6430418

18、82254.50.753.9484.54YT160M-65.53546141287.90.715.1975.975YT160M-67.511.2112056.396015319142470.713.0853.548YT132M1-642042884273.70.754.3475.000YT132M2-65.52553855285.10.775.5396.370YT160M-67.53058841319.30.756.9588.002YT160L-61135648825361.10.719.15810.532YT160L-611T35風機外形安裝圖I j-ET35、BT35、BFT35風機外形與安裝尺寸表、寸 機XABCDEFGHIJKn?d1?d2重量2.8 :2833203463551 220