1、精選優質文檔-傾情為你奉上乙醇-水精餾塔實驗一、實驗目的：1.了解板式精餾塔的結構和操作。2.學習精餾塔性能參數的測量方法，并掌握其影響因素。二、實驗內容:1.測定精餾塔在全回流條件下,穩定操作后的全塔理論塔板數和總板效率。2.測定精餾塔在部分回流條件下,穩定操作后的全塔理論塔板數和總板效率。三、實驗原理： 對于二元物系，如已知其汽液平衡數據，則根據精餾塔的原料液組成，進料熱狀況，操作回流比及塔頂餾出液組成，塔底釜液組成可以求出該塔的理論板數NT.按照式1可以得到總板效率ET,其中NP為實際塔板數。ET （1）部分回流時，進料熱狀況參數的計算式為 （2）式中： tF 進料溫度， 。 tBP 進

2、料的泡點溫度， 。 Cpm 進料液體在平均溫度（tF+ tP）/2下的比熱，kJ/（kmol ） rm 進料液體在其組成和泡點溫度下的汽化潛熱，kJ/kmol kJ/（kmol ） （3） kJ/kmol （4）式中： CP1， CP2 分別為純組份1和組份2在平均溫度下的比熱，kJ/（kg ）。 r1,r2 分別為純組份1和組份2在泡點溫度下的汽化潛熱，kJ/kg。M1，M2分別為純組份1和組份2的摩爾質量，kJ/kmol。x1,x2分別為純組份1和組份2在進料中的摩爾分率。四、實驗裝置基本情況:1實驗設備流程圖（如圖1所示）：圖1 精餾實驗裝置流程圖1-儲料罐；2-進料泵；3-放料閥；4-

3、加熱器；5-直接進料閥； 6-間接進料閥；7-進料流量計；8-高位槽；9-玻璃觀察段； 10-精餾塔；11-塔釜取樣閥；12-釜液放空閥；13-塔頂冷凝器； 14-回流比流量計；15-塔頂取樣閥；16-塔頂液回收罐； 17-放空閥；18-冷卻水流量計；19-塔釜儲料罐；20-塔釜冷凝器； 21-第8塊板進料閥；22-第9塊板進料閥；23-第10塊板進料閥； 24-液位計；25-料液循環閥；26-釜殘液出料閥;27-進料入口閥；28-指針壓力表2.實驗設備主要技術參數：精餾塔實驗裝置結構參數見表1： 表1 精餾塔結構參數名稱直徑（mm）高 度（mm）板間距（mm）板 數(塊)板型、孔徑（mm）材

4、 質塔體76×3.510010011篩板2.0不銹鋼塔釜220×2400不銹鋼塔頂冷凝器89×3.5600不銹鋼塔釜冷凝器57×3.5300不銹鋼表2 乙醇水 t-x-y 關系 (以乙醇摩爾分率表示，x-液相，y-氣相 )摩爾分數x摩爾分數yt/0.000 0.000 1000.050 0.310 90.60.100 0.430 86.40.200 0.520 83.20.300 0.575 81.70.400 0.614 80.70.500 0.657 79.90.600 0.698 79.10.700 0.755 78.70.800 0.820 78

5、.40.894 0.894 78.150.950 0.942 78.31.000 1.000 78.3乙醇沸點: 78.3; 水沸點:100.0.3實驗儀器及試劑：（1）實驗物系：乙醇水（本試驗也可用乙醇-正丙醇物系）；（2）實驗物系純度要求: 化學純或分析純； （3）實驗物系平衡關系見表2；（4） 實驗物系濃度要求: 15-25(乙醇質量百分數)，濃度分析使用酒精計，酒精計為體積分數， 通過查酒精體積分數、質量分數、密度對照表可得酒精的質量分數W，通過質量分率求出摩爾分率(X)，公式如下: 乙醇分子量46; 水分子量B183實驗設備面板圖（如圖2所示）：圖2 精餾設備儀表面板圖五、實驗方法及

6、步驟： 1.實驗前檢查準備工作： 配制一定濃度(質量濃度 20左右)的乙醇水混合液(總容量25升左右),倒入儲料罐中。打開進料入口閥27，其余閥門關閉，啟動進料泵2，打開料液循環閥25，使料液混合均勻，混合均勻后將料液循環閥25打至半開，將直接進料閥全開，放空閥12全開，進行進料，一般在塔釜總高2/3處。然后關閉進料閥門和進料泵。2. 實驗操作：(1)全回流操作： 打開塔頂冷凝器進水閥門,保證冷卻水足量（160L/h即可）。 記錄室溫。接通總電源開關（220V）。 調節加熱電壓約為150伏, 待塔板上建立液層后再適當加大電壓至170V，使塔內維持正常操作。 當各塊塔板上鼓泡均勻后,保持加熱釜電

7、壓不變, 在全回流情況下穩定20分鐘左右。期間要隨時觀察塔內傳質情況直至操作穩定。然后分別在塔頂、塔釜取樣口用100ml量筒同時取樣，通過酒精計分析樣品濃度。(2)部分回流操作：打開間接進料閥門和進料泵，調節轉子流量計, 以3.0-4.0（Lh)的流量向塔內加料，打開進料加熱開關，調節到合適的進料溫度，用回流比流量計調節回流比為 R3 ，餾出液收集在塔頂液回收罐中。塔釜產品經冷卻后由溢流管流出,收集在容器內。待操作穩定后,觀察塔板上傳質狀況,記下加熱電壓、塔頂溫度，塔釜壓力等有關數據,整個操作中維持進料流量計讀數不變,分別在塔頂、塔釜和進料三處取樣,用酒精計其濃度并記錄下進塔原料液的溫度。 (

8、3)實驗結束取好實驗數據并檢查無誤后可停止實驗，此時關閉進料閥門和加熱開關，關閉回流比流量計閥門。 停止加熱后10分鐘再關閉冷卻水,一切復原。根據物系的 t-x-y 關系,確定部分回流條件下進料的泡點溫度，并進行數據處理。六、實驗注意事項：1.由于實驗所用物系屬易燃物品，所以實驗中要特別注意安全,操作過程中避免灑落以免發生危險。2.本實驗設備加熱功率由儀表自動調節，注意控制加熱升溫要緩慢，以免發生爆沸(過冷沸騰)使釜液從塔頂沖出。若出現此現象應立即斷電，重新操作。升溫和正常操作過程中釜的電功率不能過大。3.開車時要先接通冷卻水再向塔釜供熱，停車時操作反之。4.檢測濃度使用酒精計，使用方法見說明

9、書 。5.為便于對全回流和部分回流的實驗結果(塔頂產品質量)進行比較, 應盡量使兩組實驗的加熱電壓及所用料液濃度相同或相近。連續開出實驗時, 應將前一次實驗時留存在塔釜、塔頂、塔底產品接受器內的料液倒回原料液儲罐中循環使用。七、實驗數據記錄表4 精餾實驗原始數據實際塔板數：11 實驗物系：乙醇-水 全回流：R = ，塔釜壓力 = kPa部分回流：R =3 進料量：4 l/h進料溫度：60 塔頂組成塔釜組成塔頂組成塔釜組成進料組成體積分數附錄 酒精體積分數、質量分數、密度對照表體積分數質量分數體積分數質量分數體積分數質量分數0033.427.521766.859.01810.10.079133.

10、527.607866.959.12230.20.158233.627.69436759.22660.30.237333.727.780767.159.3310.40.316333.827.86767.259.43540.50.395633.927.953267.359.53980.60.47483428.039867.459.64440.70.55434.128.126467.559.74890.80.633334.228.21367.659.85420.90.712634.328.299667.759.958910.791834.428.386367.860.06361.10.871234.

11、528.472967.960.16841.20.950534.628.566860.27331.31.029934.728.646768.160.37871.41.109234.828.733568.260.48391.51.138634.928.820268.360.58961.61.26813528.907168.460.69461.71.347535.128.993968.560.80051.81.42735.229.081168.660.90641.91.506535.329.16868.761.011621.58635.429.255268.861.11762.11.665535.5

12、29.342168.961.2232.21.745135.629.42916961.32912.31.824735.729.516469.161.43532.41.904335.829.603469.261.54152.51.983935.929.690869.361.64712.62.06363629.777869.461.75352.72.143336.129.865369.561.85992.82.22336.229.952769.661.96642.92.302736.330.039869.762.072932.382536.430.127369.862.17883.12.462236

13、.530.214969.962.28553.22.54236.630.30247062.39223.32.621836.730.3970.162.4993.42.701636.830.477370.262.60583.52.781536.930.564970.362.71273.62.86143730.652570.462.81963.72.941337.130.740270.562.92673.83.021237.230.827970.663.0333.93.101237.330.91670.763.140243.181137.431.003870.863.24744.13.261137.5

14、31.091670.963.35464.23.341137.631.17947163.46194.33.421137.731.267371.163.56934.43.501237.831.355571.263.67684.53.581337.931.443471.363.78434.63.66143831.531371.463.89184.73.741538.131.619371.564.00024.83.821638.231.707671.664.10794.93.901838.331.795971.764.215653.981938.431.88471.864.32345.14.06213

15、8.531.972171.964.43135.24.142438.632.06057264.53295.34.222638.732.14972.164.64725.44.302838.832.237172.264.7565.54.383138.932.325472.364.8645.64.46343932.413972.464.97315.74.543739.132.502572.565.08135.84.62439.232.591172.665.19035.94.704439.332.679472.765.299464.784839.432.768172.865.40796.14.86513

16、9.532.856872.965.51646.24.945639.632.94557365.62576.35.025939.733.034373.165.7356.45.106439.833.122773.265.84456.55.186839.933.211673.365.95326.65.26734033.300473.466.06286.75.347840.133.389373.566.17246.85.428340.233.478273.666.28216.95.508940.333.567573.766.391875.589440.433.656573.866.50097.15.67

17、0140.533.745573.966.61087.25.750640.633.83457466.72077.35.831240.733.923674.166.83077.45.911840.834.013174.266.94087.55.992540.934.102274.367.0517.66.07324134.191474.467.16127.76.153941.134.280574.567.27147.86.234641.234.370174.667.38257.96.315341.334.459774.767.49386.396141.434.54974.867.60348.16.4

18、76841.534.638374.967.7148.26.557741.634.7287567.82468.36.638441.734.817875.167.93528.46.719241.834.902775.268.0468.56.800141.934.996675.368.15768.66.8814235.086575.468.26848.76.961842.135.176375.568.37948.87.042742.235.266275.668.49048.97.123742.335.356275.768.601497.204642.435.446175.868.71349.17.2

19、85542.535.536175.968.82469.27.366542.635.62627668.93589.37.447542.735.716276.169.04729.47.528542.835.806376.269.15949.57.609542.935.896476.369.27089.67.69054335.986676.469.38329.77.771643.136.076876.569.49559.87.852643.236.167476.669.60739.97.933743.336.258176.769.719108.014843.436.348376.869.831610

20、.18.10643.536.438776.969.944310.28.177143.636.52947770.056210.38.258343.736.620277.170.169110.48.339543.836.710677.270.28210.58.420743.936.801177.370.394910.68.5024436.89277.470.507910.78.583244.136.982977.570.62110.88.664544.237.073877.670.734210.98.745844.337.164477.770.8475118.827144.437.255477.8

21、70.960811.18.908444.537.346577.971.074211.28.989744.637.43767871.187611.39.071144.737.528778.171.301211.49.152444.837.619578.271.415611.59.233844.937.710778.371.529211.69.31524537.801978.471.64311.79.396645.137.893278.571.756811.89.478145.237.984578.671.871511.99.559545.338.075878.771.9855129.64145.

22、438.167278.872.099512.19.722545.538.258678.972.214412.29.80445.638.3547972.328612.39.885645.738.441979.172.442912.49.967145.838.533479.272.55812.510.048745.938.624979.372.672412.610.13034638.716579.472.787712.710.211846.138.808179.572.902212.810.293546.238.900279.673.017712.910.375146.338.991979.773

23、.13321310.456846.439.08479.873.24813.110.538446.539.175879.973.362813.210.620146.639.26768073.478613.310.701846.739.359880.173.594413.410.783646.839.451780.273.710313.510.865346.939.54480.373.826313.610.9474739.63680.473.942313.711.028847.139.728480.574.058513.811.110647.239.820480.674.173813.911.19

24、2547.339.912880.774.29011411.274347.440.005380.874.406414.111.356147.540.097580.974.522914.211.437947.640.198174.639414.311.519847.740.282781.174.75614.411.601747.840.375381.274.873514.511.683647.940.467681.374.990214.611.76555042.425281.475.107914.711.847450.142.519281.575.224814.811.929450.242.612

25、881.675.341814.912.011450.342.706881.775.45971512.093450.442.80181.875.576915.112.175450.542.894781.975.694915.212.257450.642.98888275.812215.312.339450.743.083182.175.930515.412.421450.843.177382.276.047915.512.503550.943.272182.376.166315.612.58565143.365682.476.284815.712.667751.143.459982.576.40

26、2515.812.749851.243.554482.676.521115.912.83251.343.648982.776.63991612.914151.443.743482.876.758716.112.996351.543.837982.976.876716.213.078551.643.9338376.995616.313.160751.744.027683.177.114716.413.242951.844.122383.277.233816.513.325251.944.21783.377.35316.613.40735244.311883.477.472316.713.4896

27、52.144.406683.577.592616.813.571952.244.501983.677.712116.913.654252.344.596883.777.83161713.736652.444.691883.877.951217.113.818952.544.786783.978.070917.213.901152.644.88228478.190717.313.983552.744.977384.178.311517.414.06652.845.072484.278.431417.514.148452.945.16884.378.552417.614.23075345.2632

28、84.478.672517.714.313253.145.358984.578.793717.814.395753.245.454184.678.914917.914.47853.345.549984.779.03521814.560553.445.645384.879.156618.114.643153.545.741284.979.277218.214.722553.645.83718579.398718.314.808153.745.932585.179.520418.414.890553.846.028685.279.642118.514.973153.946.124185.379.7

29、63918.615.05585446.220285.479.885818.715.138354.146.316485.580.008818.815.220954.246.412585.680.130818.915.303554.346.508885.780.2531915.386254.446.60585.880.375319.115.468954.546.700885.980.497619.215.551554.646.79728680.6219.315.634154.746.893686.180.743519.415.716954.846.990186.280.866119.515.799

30、754.947.086586.380.989819.615.88235547.183186.481.113519.715.96555.147.279786.581.237319.816.047855.247.376886.681.360319.916.130755.347.473586.781.48432016.213455.447.570286.881.608420.116.296355.547.667586.981.731620.216.379155.647.76438781.855920.316.46255.747.861187.181.980320.416.54555.847.9588

31、7.282.105820.516.62855.948.055587.382.230320.616.71085648.152487.482.35520.716.793856.148.249587.582.480720.816.876956.248.347187.682.605620.916.959856.348.444287.782.73052117.042856.448.541987.882.855621.117.125956.548.639187.982.981721.217.20956.648.73638883.106921.317.29256.748.834188.183.233221.

32、417.375156.848.931588.283.359621.517.458356.949.029488.383.486121.617.54155749.126888.483.612721.717.624757.149.224888.583.739421.817.707757.249.322988.683.866221.917.79157.349.420588.783.99312217.874257.449.518688.884.120122.117.957557.549.616888.984.247222.218.040857.649.71518984.374422.318.124157

33、.749.813489.184.502722.418.207557.849.911289.284.631122.518.290857.950.009689.384.758522.618.3745850.10889.484.887122.718.457458.150.206589.585.015922.818.540858.250.30589.685.144722.918.624358.350.403689.785.27362318.707758.450.502289.885.401623.118.791258.550.600989.985.530723.218.874758.650.69969

34、085.659923.318.958258.750.798490.185.790223.419.011758.850.897290.285.919623.519.125458.950.996190.386.050223.619.2095951.09590.486.179823.719.292659.151.193990.586.310623.819.376259.251.292990.686.441523.919.459859.351.392690.786.57142419.543459.451.491790.886.702524.119.627159.551.590890.986.83272

35、4.219.71159.651.699186.96424.319.794759.751.789391.187.095424.419.878459.851.889191.287.22824.519.962359.951.988591.387.359624.620.04616052.087991.487.491424.720.129960.152.187391.584.624324.820.213760.252.287491.687.756324.920.297760.352.387591.787.88842520.381560.452.487191.888.020525.120.465460.5

36、52.586791.988.153925.220.549560.652.6879288.286325.320.633360.752.787392.188.419925.420.717260.852.887192.288.554725.520.801260.952.986992.388.688525.620.88536153.087492.488.823525.720.969361.153.187992.588.957625.821.053361.253.288592.689.091725.921.137561.353.388592.789.22712621.221561.453.489292.

37、889.361526.121.305861.553.589992.989.497126.221.389961.653.69079389.631726.321.474261.753.791593.189.768726.421.558361.853.891893.289.904626.521.642661.953.992793.390.041826.621.7276254.093793.490.179126.721.911262.154.194793.590.315426.821.895662.254.295893.690.45326.921.979862.354.396993.790.59072

38、722.064262.454.498193.890.728527.122.148762.554.599393.990.865327.222.23362.654.70129491.003327.322.317562.754.802594.191.142627.422.40262.854.903994.291.282127.522.486662.955.005494.391.422727.622.57096355.106894.491.562427.722.655563.155.208494.591.702227.822.740163.255.310694.691.842227.922.824563.355.412294.791.98232822.909263.455.513994.892.123628.122.993863.555.615794.992.26428.223.078563.655.71819592.404428.323.163363.755.8295.192.547328.423.24863.855.921995.292.689228.523.332863.956.024595.392.832428.623.41766456.126595.492