1、鋼絲繩電動葫蘆檢測報告Test report of wire-rope electric hoistJB/2004JB/2004規格型號 CD 10tT8m specification and type 出廠編號Manufacturing Code工作級別M3work grade檢驗日期 2012年06月 inspection date保定維佑商貿有限公司Baoding Weyou Technology Company鋼絲繩電動葫蘆檢驗記錄Test record of wire-rope electrie hoist序號No.考核項目Inspected item單位unit質量指標Qualit

2、y standard檢驗結果Test result結論conclusion備注remark1靜戦試驗Static testt試驗載荷test load：符合要求合格2動載試驗Dynamic testt試驗載荷test load:符合要求合格3降壓試驗Reduced pressureexperiment90%額定電壓試驗載荷90% rated voltage test load（Gn為額定戦荷Gn is rated load）符合要求合格4起升速度Lifting speedm/min偏差為名義值的±10%Warp is ± 10% of normal value6. 9m/m

3、in合賂5起升高度Lifting heightm偏差為名義值的-3$Warp is "3% of normal value17. 92m合賂6制動下滑址Brakeslidequantitymm試驗載荷test load 制動下滑S brake slide quantity SV/100 （V為1分鐘內實測吊鉤穩定上 升的距離 V is tested hook hoisting distance m one minute）16mm合格7起升機構噪音 Noise of lifting mechanismdB（A）試驗載荷時（when test load is 、5tW85,5t以上W90

4、72合賂8電動小午空戦噪 音 zero load noise of electric trolleydB（A）W8071合格9電動小車爬坡試 驗 climbing test of electric trolley坡度不小于 1/200 gradient not less than 1/200 試驗載荷test load：符合要求合格10運行速度Traveling speedm/min偏差為名義值的士15弔Warp is +15% of normalvalue11導繩器Rope-guide裝配合理，空鉤下降時，鋼絲繩 應能自由地從導繩器的出口排 出.Reasonable assembly, wh

5、en hook without load descends, wire rope should be put out freely from the rope-guide能自由排出合格12限位器 limiter限位開關動作可靠Limit switch should act可靠合賂reliably13鋼絲繩Wire rope有合格證且繩端固定牢靠，編繞 正確.Having certificate of approval and rope end is fixed reliably正確合賂14防護等級Protection gradeIP1 1IP44合格鋼絲繩電動葫蘆檢驗記錄Test record

6、 of wirerope electrie hoist15絕緣電阻InsulationresistorMQ>180合格16接地電阻Earth resitorQ<合格17起升減速器內余 物 sundries in hoisting reducermg<250<191合格18油漆漆膜厚度Paint film thicknessM m油漆漆膜總厚度不小于50 general thickness of paint film is no less than 50（取10處平均值get mean value from ten places * value）54合格19漆膜附肴力 A

7、dhesion of paint film應符合GB9286的規定Accord with the regulationsof GB9286符合規定合格20升壓試驗Lifting pressure test電動機和電器裝置無井常When 110% load, there is no abnormal phenomenon with the motor and electric appliance無異常合格21起升機構用減速 器的箱體蓋中心 距倫差center distance warp of body cover of reducer in lifting mechanismmmW士w合格22鉤口變形Mouth of hookdistortion%鉤11變形$不大于%Deflection quantity of hook mouth is not more than 絡%合賂23電氣設備 Electric equipment檢査是否有合格證和質檢中心 型式報告.Check if there is any certificate of approval and quality inspection report有合賂檢驗結論 test conclusion：經檢驗各項指標符合標準要求經檢驗各項指標符合JB/-200