1、CUSTOMER/客戶:FILE NO./認證號:PART NO./物料號:上海乘翔電子科技有限公司SHANGHAI CHENGXIANG ELECTRONIONICS CO.,LTD.SPECIFICATION FOR APPROVAL客戶承認書MODEL NO./產品型號:PRODUCT NO./產品編號:MAINFRAME MODEL/主機型號:MARK修改標記 (38V2A)REVISED CONTENT修改內容APPROVED & DATE認可日期AUTHORIZED SIGNATURE & COMPANY CHOP/客戶認可簽回ORIG. DATE/初始日期11.0

2、6.18EDITION/版本0PAGE/頁碼1 OF8DESIGN/擬制 鄧浩穎CHECK/審核 林洪斗APPROVAL/批準 SHANGHAI CHENGXIANG ELECTRONICS (SHENZHEN) CO., LTD./乘翔電子有限公司.ADD：Bao Tian Industrial area Xi Xang Shen Zhen/深圳市寶安區寶田工業區寶樹大廈4樓電話13917156227 傳真：021-523082611.ELECTRICAL PERFORMANCE/電氣性能SAFETY STANDARD/安規標準:The power supply s

3、hall be certified by the following international regulatory standards電源應符合下列的國際標準 2.3.DIELECTRIC WITHSTANDING STRENGTH(HI-POT)/絕緣介電強度(耐壓)(S):Primary to Secondary DC3000V, 3.5mA 1 minute for type test, 3 second for production.一次側對二次側: DC3 KV, 3.5mA標準測試1分鐘,量產測試3秒鐘.INPUT FEATURE/輸入特性:3.1 RATED INPUT VO

4、LTAGE: 100Vac to 240Vac. 額定輸入電壓范圍從100Vac到240Vac.INPUT VOLTAGE RANGE: 100Vac to 240Vac. 輸入電壓范圍從100Vac到240Vac.3.2 RATED INPUT FREQUENCY: 50/60Hz. 額定輸入頻率50/60Hz.INPUT FREQUENCY RANGE: 47Hz to 63Hz. 輸入頻率范圍從47Hz到63Hz.3.3 INPUT CURRENT: 1.5A max. at 100-240Vac. 最大輸入電流1.5A(輸入條件100-240Vac).3.4 INRUSH CURREN

5、T: 60A max. at 100-240Vac input for a cold start at 25.在冷開機條件下,最大浪涌電流不超過60A(輸入條件100-240Vac).3.5 EFFICIENCY: more than 60% at 100-240Vac input and output full load.效率高于80%(輸入100-240Vac和輸出滿載條件).4.OUTPUT FEATURE/輸出特性:RATED OUTPUT/額定輸出(I)38VDCOutput regulation/輸出電壓規格(I)Output load/輸出負載規格(I)Output curren

6、t/輸出電流規格(I)Ripple and Noise/輸出紋波及噪聲(I)SPEC. LIMIT/規格限定Min. valueMax. value37.5VDC38.5VDC0.0A2A2A4A-150mV-REMARK/備注ORIG. DATE/初始日期PRODUCT NO./產品編號110618EDITION/版本PAGE/頁碼02 OF 8V38.537.50ELECTRICAL PERFORMANCE/電氣性能CHARGE CURVE(充電曲線)2 4AORIG. DATE/初始日期PRODUCT NO./產品編號11.06.18EDITION/版本PAGE/頁碼03 OF 85.E

7、LECTRICAL PERFORMANCE/電氣性能PROTECTION FEATURE/保護特性:5.1 OVER-CURRENT PROTECTION/過電流保護:The power supply shall be proteced (hiccupped & power reduced) when any output operatingin overload condition (set Max. 8A) under any line condition for an indefinite periodof time. The power supply shall be self

8、-recovery when the fault condition is removed.在任何時候,任何輸入條件,當輸出操作在過載條件(設定最大8A)時,電源供應器將進入保護(打嗝或功率下降)模式,當過載故障被移走后,電源要能自動恢復到正常.5.2 SHORT-CIRCUIT PROTECTION/輸出短路保護:The power supply shall be proteced (hiccupped & power reduced) and no damage shall occurwhen any output operating in a short circuit cond

9、ition under any line condition for anindefinite period of time. The power supply shall be self-recovery when the faultcondition is removed.在任何時候,正常輸入條件下,當輸出操作在短路情況下,電源供應器將進入保護(打嗝或功率下降)模式,當短路故障消失后,電源要能自動恢復正常.6.MAJOR MEASURE EQUIPMENT/主要測量設備:A. AC SOURCE/交流輸入電源: AFC-500WB. POWER METER/電源功率計: Zentech 2

10、100C. ELECTRONIC LOAD/電子負載: PRODIGIT 3310CD. OSCILLOSCOPE/存儲示波器: Lecroy LT354E. DIGITAL MULTIMETER/數字式萬用表: Fluke 4.5F. DC POWER/直流輸入電源: WYK-6030G. HI-POT TESTER/耐壓測試儀: GOODWILL GPT-605ORIG. DATE/初始日期PRODUCT NO./產品編號11.06.18EDITION/版本PAGE/頁碼04 OF 8EXTERNAL VIEW/外觀圖ORIG. DATE/初始日期 11.06.18PRODUCT NO./

11、產品編號EDITION/版本PAGE/頁碼05OF 8NAME PLATE/銘牌NAME PLATE/銘牌:UNIT/單位: mmTOLERANCE/公差: +0/-0.2BACK COLOUR/底色: BLACK/黑色WORD COLOUR/字色: WHITE/白色* PLEASE ADVISE IF ANY COMMENT ON NAME PLATE INFORMATION.OTHERWISE, THIS INFORMATION IS REGARDED AS CUSTOMER APPROVAL AND APPLY IN PRODUCTION.銘牌資料供客戶樣品認可使用,如有疑問,請于樣品認

12、可前提出,否則,資料將視作客戶認可并應用于生產上.ORIG. DATE/初始日期 PRODUCT NO./產品編號11.06.18EDITION/版本PAGE/頁碼06OF 8PRODUCT/產 品:PLASTIC BAG/塑料袋:PACKING DRAWING/包裝示意圖產品MECHANICAL DIMENSION(UNIT IN cm)/尺寸(單位 cm):LWHCARDBOARD/刀 卡：PLASTIC BAG/塑料袋（小）PLASTIC BAG/塑料袋（大）PAPER CASE/紙箱PACKING METHOD/包裝方式：CARDBOARD/紙板:PAPER CASE/紙 箱:REMA

13、RK/備注:1.STORAGE CONDITION/保存條件TEMPERATURE/保存溫度:-10+60RELATIVE HUMIDITY/相對濕度: 30%80%PACKING METHOD /裝箱方式QTY/裝箱總數N.G/單個成品凈重G.W/毛重2.STORAGE TIME/保存時間: 6 MONTHES/6個月3.ANLISTATIG: NO REQUIREMENT/無抗靜電要求.4.PLEASE ADVISE IF ANY COMMENT ON PACKING INFORMATION,OTHERWISE,THISINFORMATION IS REGARDED AS CUSTOMER

14、 APPROVAL AND APPLY IN PRODUCTION.包裝資料供客戶樣品認可使用,如有疑問,請于樣品認可前提出,否則,資料將視作客戶認可并應用于生產上.ORIG. DATE/初始日期11.06.18EDITION/版本PRODUCT NO./產品編號PAGE/頁碼70OF8 H ± 0.3 L +2.0 0 H +2.0 0 W +2.0 0 W ± 0.5 L ± 0.5 W ± 0.5 L ± 0.5 L ± 1.5 W ± 1.5 PR ODUCTCUSTOMER/客戶MODEL NO./產品型號SAMP

15、LE PRIMARY TEST REPORT/樣品初測報告PRODUCT NO./產品編號TestSample quantity and test result/樣品數量和測試結果Test Items./測試項目Condition/測試條件Unit/單位1#Pass/FailUnload outputvoltage/空載輸出電壓(0.0A)12Vdc -12.7VdcRated load outputvoltage/額定負載輸出電壓(5.0A)11.5Vdc - 12.7VdcOutput ripple & noisevoltage/輸出紋波及噪聲電壓150mVShort-circuitprotection test/短路保護測試Over currentprotection/過流保護點(4A)strike times/沖擊100Vac132Vac180Vac240Vac100Vac132Vac180Vac240Vac100Vac132Vac180Vac240Vac100Vac240Vac100Vac240Vac100 Vac240 VacV38.3V38.3V38.3V12.55V38.3V38.3V38.3V38.3mV5